Product ID:S-515 CLEAR THIN-SPREAD ADHESIVE
MSDS Date:11/16/1992
FSC:8040
NIIN:00N038168
MSDS Number: CGYGQ

ARMSTRONG WORLD INDUSTRIES INC

313 W LIBERTY ST
LANCASTER, PA 17604
US

Emergency Phone: 717-396-2328

Info Phone: 717-396-2935

Cage: 6F167

ARMSTRONG WORLD INDUSTRIES INC

LANCASTER, PA 17604 US

Telephone: 717-396-2328;717-396-2935

Cage: 6F167

VM & P NAPHTHA

CAS: 64742-89-8

Fraction By Weight: 2-4%

OSHA PEL N/K

ACGIH TLV: N/K

TOLUENE (SARA 313) (CERCLA)

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 2-10%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN: EXCESSIVE SKIN CONTACT MAY CAUSE
DRYING & CRACKING OF SKIN, DEFATTING OF TISSUE & RESULT IN
DERMATITIS. EYES: CONTACT W/EYES WILL CAUSE IRRITATION. INHALATION:
VM&P NAPHTHA & TOLUENE ARE KNONW T O CAUSE IRRITATION OF
RESPIRATORY TRACT, COUGHING & CNS EFFECTS SUCH AS HEADACHE,
DIZZINESS, DROWSINESS(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: & UNCOORDINATED MOVEMENTS. CHRONIC:
TOLUENE APPEARS ON THE NAVY LIST OF OCCUPATIONAL CHEMICAL
REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM APPROPRIATE HEALTH
PROFESSIONALS CONCERNING LATEST HAZARD LIST INFO & SAFE HANDLING &
EXPOSURE INFO . TARGET ORGANS: UPPER RESPIRATORY TRACT, SKIN, EYES.
Medical Cond Aggravated by Exposure:ANY CONDITION GENERALLY AGGRAVATED
BY SOLVENTS, INCLUDING PREEXISTING UPPER RESPIRATORY AND LUNG
DISEASE SUCH AS BUT NOT LIMITED TO BRONCHITIS, EMPHYSEMA AND
ASTHMA. EXISTING SKIN CONDITIONS.

First Aid:SKIN: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN & GET IMMED
MED ATTN. WASH W/SOAP & WATER. REFER TO MD IF IRRIT OR SYMPTOMS
PERSIST. EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN & GET
IMMED MED ATTN. INHAL: REMOVE TO FRESH AIR IF EXPOSED TO EXCESS
CONCENTRATIONS OF VAPOR. SEEK MED ATTTN IF SYMPTOMS PERSIST.
INGEST: DO NOT INDUCE VOMITING. CALL POISON CONTROL CENTER OR MD
FOR GUIDANCE.

Flash Point Method:SCC
Flash Point:>210F,>99C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, HALON, WATER SPRAY.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS IN A FIRE MAY RUPTURE
DUE TO PRESSURE BUILD-UP; USE WATER TO COOL CONTAINERS TO PREVENT
THIS.

Spill Release Procedures:VENTILATE AREA OF SPILL OR RELEASE. WEAR EYE
PROTECTION EQUIPMENT. SCRAPE UP PRODUCT AND PLACE INTO CONTAINER.
RESIDUAL OF PRODUCT, WHILE STILL WET, CAN BE CLEANED UP WITH WARM
SOAPY WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN AN AREA SUITABLE FOR
COMBUSTIBLE MIXTURES. RECOMMENDED STORAGE TEMPERATURE IS BELOW 90F.
Other Precautions:VAPORS ARE HEAVIER THAN AIR. USE PRECAUTIONS THAT ARE
COMMON WITH THE SAFE HANDLING OF COMBUSTIBLE LIQUIDS. WARNING: THIS
PRODUCT CONTAINS TOLUENE, A CHEMICAL KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRO HARM.

Respiratory Protection:WITH ADEQUATE VENTILATION, RESPIRATORY EQUIPMENT
SHOULD NOT BE NEEDED. IF ADEQUATE VENTILATION IS NOT AFFORDED, WEAR
NIOSH APPROVED RESPIRATORY EQUIPMENT APPROVED FOR ORGANIC VAPORS.
Ventilation:USE NATURAL CROSS-VENT, LOCAL (MECHANICAL) PICK-UP &/OR
GENERAL AREA (MECHANICAL) VENT TO PREVENT ACCUMULATION (SUPDAT)
Protective Gloves:COTTON OR LOOP-PILE GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
VENT: OF SOLVENT VAPORS, KEEPING IN MIND THAT THE VENT PATTERN MUST
REMOVE THE HEAVIER-THAN-AIR SOLVENT VAPORS FROM THE LOWER LEVELS OF
THE WORK SPACES. THE VENT SHOULD BE SUFFICIENT TO KEEP THE SOLVE NT
VAPOR CONCENTRATION BELOW THE TLV.

Boiling Pt:B.P. Text:>210F,>99C
Vapor Density:HVR/AIR
Spec Gravity:1.00 (H*2O=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:CLEAR ADHESIVE WITH SLIGHT AROMATIC ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE &
OTHER TOXIC VAPS & GASES THAT ARE COMMON TO THERMAL DEGRADATION OR
ORGANIC COMPOUNDS.

Waste Disposal Methods:INCINERATION OR OTHER APPROVED METHOD IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS. THIS PRODUCT
CONTAINS CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION
313 OF TITLE III OF SARA AND 40 CFR PART 372.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.